United States and Foreign Patents Granted - These products are protected under one or more of the following U.S. and foreign patents:

5,370,722 • 5,529,593 • 6,197,077 B1 • 2170244 • 95904185 • 6-2113 • 7,323,028 • 7,416,577 • 8,726,954 B2 • 7,416,577 B2 • 7,842,116 B2 • Other Patents Pending.

Call Us At: (800) 819-2869

Category Archives: Article

NY Legionella Outbreaks Turns up The Heat on Cooling Tower Maintenance

legionella1 Written By: Randy Simmons, President, Air Solution Company

According to a New York Times Report, since the deadly outbreak of Legionnaires’ disease at the Opera House Hotel in the South Bronx was discovered in July, twenty of the more than 135 other cooling towers tested were found to be infected with the Legionella bacteria. This prompted the NYC Health Dept. to send a letter to every building in the city with a cooling tower ordering that they evaluate and disinfect their tower within two weeks of receiving the letter.

Following the actions of the NYC Health Dept. Mayor DeBlasio signed into law that cooling towers be regulated. The legislation requires the registration of all cooling towers, annual certification, quarterly inspection, and reporting of increased microbes to the Department of Health and Mental Hygiene. The legislation also mandates the disinfection of cooling towers with levels of microbes that pose potential health risks. Violations of registry, certification and inspection requirements are liable for civil penalties up to $10,000. Failure to disinfect towers with increased microbes are classified as misdemeanors, punishable up legionella2to $25,000.

The legislation takes effect immediately, and building owners were given 30 days to register their cooling towers. The DeBlasio administration, New York City Council, and Governor Cuomo collaborated closely on the policy to ensure consistency in regulation in New York City and across the state. NYC is the first major city in the US to regulate the use of cooling towers.  This new legislation is a pre-emptive action to prevent future illness. The New York City Outbreak claimed 12 lives and sickened more than 120 others in the South Bronx, making this the worst Legionella outbreak in the city’s history.  Legionella in cooling towers and other building systems (boilers, potable water, etc.) unfortunately isn’t new news, but has been a topic of robust discussion across the country and around the world for many years and in many countries around the world. In many countries including the UK and Australia, cooling towers must be registered and are closely regulated by Health and Safety officials; With the NYC outbreak occurring on the heels of ASHRAE releasing its ANSI/ASHRAE Standard 188-2015 Legionellosis: Risk Management for Building Water Systems. Air Solution Company foresees that there will be increasing regulations placed on the use of cooling towers across North America.

What Air Intake Filtration Can Do To Help in the Prevention of Legionella in Cooling Towers?

legionella3 Legionella bacteria are found in groundwater, lakes, rivers, ponds and man-made water systems such as plumbing systems, boiler systems and cooling towers. Though not a problem in nature, legionella can become a problem in contained / looped systems when bacterial concentrations can increase to dangerous levels which can be harmful to human life. The ideal conditions required for legionella are those with a temperature range of 77 – 113 degrees Fahrenheit and which include organic matter as a nutrient source (leaves, bugs, sediment, sludge, rust and scale) – Cooling tower and evaporative condensers provide just that environment when effective maintenance practices aren’t deployed. Cooling towers that are well managed and treated with water treatment chemicals are at lower risk however, if regular maintenance isn’t carried out, the debris loads can increase beyond the chemical concentrations ability to provide control and when this happens the tipping point is reached and the cooling tower can silently become hazardous. So what is one to do?

legionella4

Maintenance Strategies

The first step is to completely clean the tower, then deploy maintenance strategies that ensure a clean and unfavorable environment for bacterial growth – the New ANSI/ASHRAE Standard 188-215 is the best place to go for guidance. Secondly and consistent with the ASHRAE guideline for keeping debris out of the tower – is deploying the use of Air Intake Filter Screens (commonly called “Cottonwood Filter Screens”).

This highly effective device is proven to significantly reduce organic loading by stopping airborne debris at its point of entry where it can be easily removed using a broom, brush, shop vacuum or garden hose – rain can even help by rinsing them clean when fan motors are in the off cycle. In combination with an effective water management program, air intake filter screens significantly reduces organic debris which is the legionella5nutrient source that supports bacterial proliferation.

Further, this device is designed to increase laminar air flow which introduces more air to the entire face of the Fill Pack – this results in an increase in the evaporative capacity of the fill thus increasing tower efficiency and further reducing water temperatures at the basin – This translates into energy cost savings.  Because most legionella infected towers are known to be dirty and loaded with organic matter, Air Solution Company recommends that companies seeking to improve their cooling tower water quality do the easy thing first and install intake filter screens that helps stop organic debris from getting into their cooling towers in the first place.

Randy Simmons is President, Air Solution Company A manufacturer of filter screens specifically engineered for use on cooling towers, chillers and other mechanical systems.

Air Solution Company: Helping to Maintain Healthy Evaporative Cooling Systems Legionnaire’s Disease (Legionellosis) and Evaporative Cooling System Maintenance Recommendations What is Legionnaire’s Disease It is a bacterial infection that is characterized by pneumonia. According to the Center for Disease Control (CDC), legionnaire’s disease is caused by bacteria known as Legionella pneumophila. There are at least…Continue Reading

Cooling Tower Safety and Maintenance

Aligning Debris Management and Water Treatment Procedures Is Key to Cooling Tower Safety and EfficiencyBy Randy SimmonsThe following is an important reminder of the need for all companies that use cooling towers, to adopt and keep diligent in their maintenance and water treatment program. Why? because what’s at stake is a companies worker health and…Continue Reading

Air Intake Filtration Prevents & Solves Air Intake Problems

Improves Environmental Air Quality and Process Cooling Efficiency Today more than ever before, mechanical, maintenance and process engineers are being challenged to provide effective solutions that help to optimize environmental air quality and process cooling efficiency, while reducing downtime and maintenance cost. Regardless of the technology used to process incoming fresh air, the challenge has…Continue Reading

Periodic Cicadas Will Emerge In 16 States In 2004

They Can Overwhelm Your Cooling Towers, Evaporative Condensers and Air Handling Units If You’re Not Prepared! Photos – Courtesy Dottie Tison By Randy SimmonsDid you ever wonder what insects make that very loud buzzing sound in trees during the daytime in summer? Well, it’s a widely heard but rarely seen kind of insect called a…Continue Reading

The Disastrous Effects of Deferring Maintenance

By David Tod GeaslinWhen we attempt to force maintenance spending into specific lumps of time that do not meet the needs of our machines, we create the need to defer maintenance. Maintenance budgets fail because final budgeting authorities do not understand the disastrous consequences of deferring maintenance.In 2001, I was asked to create a 16-week…Continue Reading

Process Chillers & Condensing Coil Maintenance

Process Chillers & Condensing Coil Maintenance Balancing Deferred Maintenance Risks With Maintenance and Budgetary Decisions By Randy Simmons As most facilities and maintenance engineers know, proper maintenance on chiller and condensing units is critical to efficient, trouble free operation. However when you combine the fact that most chillers and condensing units are situated in low…Continue Reading

Healthcare Facility Chiller & Condensing Coil Maintenance

Balancing Deferred Maintenance Risks With Maintenance and Budgetary Decisions By Randy Simmons As most healthcare facilities and maintenance engineers know, proper maintenance on chiller and condensing units is critical to efficient, trouble free operation. However when you combine the fact that most chillers and condensing units are situated in low traffic locations and out of…Continue Reading

School District Chiller & Condensing Coil Maintenance

Balancing Deferred Maintenance Risks With Maintenance and Budgetary Decisions By Randy Simmons As most school district directors and maintenance engineers know, proper maintenance on chiller and condensing units is critical to efficient, trouble free operation. However when you combine the fact that most chillers and condensing units are situated in low traffic locations and out…Continue Reading